Char-Broil 463270614 Handleiding

Char-Broil Barbecue 463270614

Lees hieronder de 📖 handleiding in het Nederlandse voor Char-Broil 463270614 (40 pagina's) in de categorie Barbecue. Deze handleiding was nuttig voor 35 personen en werd door 2 gebruikers gemiddeld met 4.5 sterren beoordeeld

Pagina 1/40

Char-Broil Performance T-22D

463270614

08 16 13 • G351-001-210801/ /

during assembly, please call 1-888-430-7870.

l’assemblage, S’il vous plaît appelez 1-888-430-7870

durante el Ensamblado, llámenos Al 1-888-430-7870

DANGER

DANGER: Indicates an imminently hazardous situation

which, if not avoided, will result in death or serious injury.

WARNING: Indicates a potentially hazardous situation

which, if not avoided, could result in death or serious

injury.

CAUTION

CAUTION: Indicates a potentially hazardous situation

or unsafe practice which, if not avoided, may result in

minor or moderate injury.

TABLE OF CONTENTS

Safety Symbols

The symbols and boxes shown below explain what each

heading means. Read and follow all of the messages found

throughout the manual.

THIS GRILL IS FOR OUTDOOR

USE ONLY.

Read and follow all safety statements, assembly

instructions, and use and care directions before

attempting to assemble and cook.

INSTALLER/ASSEMBLER:

Leave this manual with consumer.

CONSUMER:

Keep this manual for future reference.

Failure to follow all manufacturer’s instructions could

result in serious personal injury and/or property

damage.

Some parts may contain sharp edges. Wear

protective gloves if necessary.

For residential use only. Do not use for

commercial cooking.

WARNING

DANGER

If you smell gas:

1. Shut off gas to the appliance

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

WARNING

1. Do not store or use gasoline or other

flammable liquids or vapors in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use

shall not be stored in the vicinity of

this or any other appliance.

WARNING

CAUTION

WARNING

CALIFORNIA PROPOSITION 65

1. Combustible by-products produced when using

this product contains chemicals known to the State

of California to cause cancer, birth defects, or other

reproductive harm.

2. This product contains chemicals, including lead

and lead compounds, known to the State of

California to cause cancer, birth defects or other

reproductive harm.

Wash your hands after handling this product.

WARNING

Do not attempt to repair or alter the

hose/valve/regulator for any “assumed” defect.

Any modification to this assembly will void your

warranty and create the risk of a gas leak and fire.

Use only authorized replacement parts supplied by

manufacturer.

Installation Safety Precautions

•Use grill, as purchased, only with LP (propane) gas

and the regulator/valve assembly supplied. If your grill

is Dual Fuel ready, a conversion kit must be

purchased for use with natural gas.

•Grill installation must conform with local codes, or in

their absence of local codes, with either the National

Fuel Gas Code, ANSI Z223.1/ NFPA 54, Natural Gas

and Propane Installation Code, CSA B149.1, or

Propane Storage and Handling Code, B149.2.

•All electrical accessories (such as rotisserie) must be

electrically grounded in accordance with local codes, or

National Electrical Code, ANSI / NFPA 70 or Canadian

Electrical Code, CSA C22.1. Keep any electrical cords

and/or fuel supply hoses away from any hot surfaces.

•This grill is safety certified for use in the United States

and/or Canada only. Do not modify for use in any other

location. Modification will result in a safety hazard.

CAUTION

Grease Fires

• Putting out grease fires by closing the lid is

not possible. Grills are well ventilated for

safety reasons.

• Do not use water on a grease fire. Personal injury

may result. If a grease fire develops, turn knobs

and LP tank off.

• If grill has not been regularly cleaned, a grease fire

can occur that may damage the product. Pay close

attention while preheating or burning off food

residue to insure that a grease fire does not

develop. Follow instructions on General Grill

Cleaning and Cleaning The Burner Assembly to

prevent grease fires.

• The best way to prevent grease fires is

regular cleaning of the grill.

CAUTION

Using pots larger than 6 quarts in capacity could

exceed weight limit of the side burner shelf or side

shelf, resulting in failure of grill cart components.

DANGER

•NEVER store a spare LP cylinder under or near

the appliance or in an enclosed area.

•Never fill a cylinder beyond 80% full.

If you see, smell or hear gas escaping,

immediately get away from the LP

cylinder/appliance and call your fire department.

•

An over filled or improperly stored cylinder is a

hazard due to possible gas release from the safety

relief valve. This could cause an intense fire with

risk of property damage, serious injury or death.

•

For Your Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5

Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Parts Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-30

Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . 31-32

Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

LP Cylinder Removal, Transport and Storage

•Turn OFF all control knobs and LP cylinder valve. Turn

coupling nut counterclockwise by hand only - do not use

tools to disconnect. Loosen cylinder screw beneath

bottom shelf or disconnect other retention means, then lift

LP cylinder up and and out of cart. Install safety cap onto

LP cylinder valve. Always use cap and strap supplied

with valve. Failure to use safety cap as directed may

result in serious personal injury and/or property

damage.

•A disconnected LP cylinder in storage or being

transported must have a safety cap installed (as

shown). Do not store an LP cylinder in enclosed

spaces such as a carport, garage, porch, covered patio

or other building. Never leave an LP cylinder inside a

vehicle which may become overheated by the sun.

•Do not store an LP cylinder in an area where children play.

OPD Hand Wheel

LP (Liquefied Petroleum Gas)

•LP gas is nontoxic, odorless and colorless when

produced. For Your Safety, LP gas has been given an

odor (similar to rotten cabbage) so that it can be smelled.

•LP gas is highly flammable and may ignite unexpectedly

when mixed with air.

LP Cylinder Filling

•Use only licensed and experienced dealers.

• must purge new cylinderLP dealer before filling.

• NEVERDealer should fill LP cylinder more than 80% of

LP cylinder volume. Volume of propane in cylinder will

vary by temperature.

•A frosty regulator indicates gas overfill. Immediately close

LP cylinder valve and call local LP gas dealer for

assistance.

•Do not release liquid propane (LP) gas into the

atmosphere. This is a hazardous practice.

•To remove gas from LP cylinder, contact an LP dealer or

call a local fire department for assistance. Check the

telephone directory under “Gas Companies” for nearest

certified LP dealers.

LP Cylinder Valve

Retainer Strap

Safety Cap

LP Cylinder

•The LP cylinder used with your grill must meet

the following requirements:

•Use LP cylinders only with these required

measurements: 12" (30.5cm) (diameter) x 18" (45.7

cm) (tall) with 20 lb. (9 kg.) capacity maximum.

•LP cylinders must be constructed and marked in

accordance with specifications for LP cylinders of the

U.S. Department of Transportation (DOT) or for Canada,

CAN/CSA-B339, cylinders, spheres and tubes for

transportation of dangerous goods, Transport Canada

(TC). See LP cylinder collar for marking.

•LP cylinder valve must have:

•Type 1 outlet compatible with

regulator or grill.

•Safety relief valve.

•UL listed Overfill Protection Device (OPD). This OPD

safety feature is identified by a unique triangular hand

wheel. Use only LP cylinders equipped with this

type of valve.

•LP cylinder must be arranged for vapor withdrawal

and include collar to protect LP cylinder valve.

Always keep LP cylinders in upright position

during use, transit or storage.

LP cylinder in upright position for

vapor withdrawal

USE AND CARE

LP Cylinder Exchange

•Many retailers that sell grills offer you the option of

replacing your empty LP cylinder through an exchange

service. Use only those reputable exchange companies

that inspect, precision fill, test and certify their cylinders.

Exchange your cylinder only for an OPD safety

feature-equipped cylinder as described in the "LP

Cylinder" section of this manual.

•Always keep new and exchanged LP cylinders in upright

position during use, transit or storage.

•Leak test new and exchanged LP cylinders BEFORE

connecting to grill.

•Place safety cap on cylinder valve outlet whenever the

cylinder is not in use. Only install the type of safety cap

on the cylinder valve outlet that is provided with the

cylinder valve. Other types of caps or plugs may result in

leakage of propane.

LP Cylinder Leak Test

For your safety

•Leak test must be repeated each time LP cylinder is

exchanged or refilled.

•Do not smoke during leak test.

•Do not use an open flame to check for gas leaks.

•Grill must be leak tested outdoors in a well-ventilated

area, away from ignition sources such as gas fired or

electrical appliances. During leak test, keep grill away

from open flames or sparks.

•Use a clean paintbrush and a 50/50 mild soap and water

solution. Brush soapy solution onto areas indicated by

arrows in figure below.

▲ Do not use household cleaning agents. Damage to

gas train components can result.

WARNING

If bubbles appear do not use or move the LP “growing”

cylinder. Contact an LP gas supplier or your fire

department!

Connecting Regulator to the LP Cylinder

1.LP cylinder must be properly secured onto grill. (Refer

to assembly section.)

2.Turn all control knobs to the OFF position.

3.Turn LP cylinder OFF by turning hand-wheel clockwise

to a .full stop

4.Remove the safety cap from LP cylinder valve. Always

use cap and strap supplied with valve.

OPD Hand Wheel

Safety Relief Valve

Strap and Cap

Type 1 outlet with

thread on outside

Do not use a POL transport

plug (plastic part with

external threads)! It will

defeat the safety feature of

the valve.

5.Hold regulator and insert nipple into

LP cylinder valve. Hand-tighten the

coupling nut, holding regulator in a

straight line with LP cylinder valve

so as not to cross-thread the

connection.

Nipple has to be centered

into the LP cylinder valve.

Straight

Hold coupling nut

and regulator as

shown for proper

connection to LP

cylinder valve.

6.Turn the coupling nut clockwise and tighten to a full stop.

The regulator will seal on the back-check feature in the

LP cylinder valve, resulting in some resistance. An

additional one-half to three-quarters turn is required

to complete the connection. Tighten by hand only –

do not use tools.

NOTE:

If you cannot complete the connection, disconnect

regulator and repeat steps 5 and 6. If you are still unable

to complete the connection, do not use this regulator!

DANGER

• Do not insert any tool or foreign object into the valve

outlet or safety relief valve. You may damage the

valve and cause a leak. Leaking propane may result

in explosion, fire, severe personal injury, or death.

Coupling nut

Product specificaties

Merk:	Char-Broil
Categorie:	Barbecue
Model:	463270614
Kleur van het product:	Roestvrijstaal
Warmtebron:	Gas
Gewicht:	45360 g
Breedte:	556 mm
Diepte:	1168 mm
Hoogte:	889 mm
Soort:	Grill
Gebruikershandleiding:	Ja
Ingebouwde functie:	Nee
Vormfactor:	Haard
Totaal vermogen:	- W
Zwenkwieltjes:	Nee
Kookoppervlakte vorm:	Vierkant
Benen:	Ja