Hatco FR-9B Handleiding

Hatco Heater FR-9B

Lees hieronder de 📖 handleiding in het Nederlandse voor Hatco FR-9B (9 pagina's) in de categorie Heater. Deze handleiding was nuttig voor 32 personen en werd door 2 gebruikers gemiddeld met 4.5 sterren beoordeeld

Pagina 1/9
© 2012 Hatco Corporation
Sanitizing Sink Heaters and
Food Rethermalizers/Bain-Marie Heaters
3CS and FR Series
Installation and Operating Manual
P/N 07.04.114.00
POWER
ON
LOW WATER
REFILL & RESET
PARTS & SERVICE
ASSIST ANCE
www.hatcocorp.com
800-558-0607
Fill sink before turni ng p ower o n.
Disco nnect p ower b efore se rvicin g heater .
RESET
ON
OFF
WATER HEATER
HAT CO C ORP. MILWAU KEE, WI U .S.A
U.S. PAT. NO. 3291965 CAN. PAT. NO. 761083
POWER
ON
WATER AT
TEMPERA TURE
PARTS & SER
VICE
ASSIS TANCE
www.h atcocorp.com
800-558-0607
Fill sink before turnin g power on.
Drain and clean hea te
r daily.
RESET
ON
OFF
WATER HEATER
HATCO CORP. MILWAUKEE, WI U .S.A
U.S. PAT
. NOS. 3291965 3636308
Do not operate this equipment unless you
have read and understood the contents of
this manual! Failure to follow the
instructions contained in this manual may
result in serious injury or death. This
manual contains important safety
information concerning the maintenance,
use, and operation of this product. If
you’re unable to understand the contents
of this manual, please bring it to the
attention of your supervisor. Keep this
manual in a safe location for future
reference.
No opere este equipo al menos que haya
leído y comprendido el contenido de este
manual! Cualquier falla en el seguimiento
de las instrucciones contenidas en este
manual puede resultar en un serio lesión
o muerte. Este manual contiene
importante información sobre seguridad
concerniente al mantenimiento, uso y
operación de este producto. Si usted no
puede entender el contenido de este
manual por favor pregunte a su
supervisor. Almacenar este manual en
una localización segura para la referencia
futura.
Ne pas utiliser cet équipement sans avoir
lu et compris le contenu de ce manuel !
Le non-respect des instructions
contenues dans ce manuel peut entraîner
de graves blessures ou la mort. Ce
manuel contient des informations
importantes concernant l'entretien,
l'utilisation et le fonctionnement de ce
produit. Si vous ne comprenez pas le
contenu de ce manuel, veuillez le signaler
à votre supérieur. Conservez ce manuel
dans un endroit sûr pour pouvoir vous y
référer plus tard.
WARNING
ADVERTENCIA
AVERTISSEMENT
Register Online!
(see page 2)
www.hatcocorp.com
Important Owner Information ..............................................2
Introduction...........................................................................2
Important Safety Information...............................................3
NSF Criteria.....................................................................4
Model Description.................................................................5
All Models ........................................................................5
3CS Models .....................................................................5
FR Models.......................................................................5
FRC Models ....................................................................5
Model Designations..............................................................5
Specifications........................................................................6
Plug Configurations .........................................................6
Electrical Rating Chart—3CS Models..............................6
Electrical Rating Chart—FR Models................................8
Electrical Rating Chart—FRC Models .............................9
Dimensions....................................................................10
Installation ............................................
General ..........................................................................11
Sizing Information ..........................................................11
Installing 3CS and FR Models .......................................11
Installing FRC Models....................................................13
Electrical Information .....................................................13
Operation.............................................
General..........................................................................14
Maintenance ...........................................
General..........................................................................15
Cleaning ........................................................................15
Remove Lime and Mineral Deposits..............................16
Draining Heater for Service Protection ..........................16
Resetting the Energy Cut-Off Switch (ECO)..................16
Troubleshooting Guide ...................................
Options and Accessories..................................
Limited Warranty........................................
Authorized Parts Distributors............................Bac
IMPORTANT OWNER INFORMATION
Record the model number, serial number (located on the lower
right side on the front of the unit), voltage and purchase date of
your Water Heater in the spaces below. Please have this
information available when calling Hatco for service assistance.
Model No. ____________________________________
Serial No. ____________________________________
Voltage ______________________________________
Date of Purchase ______________________________
Register your unit!
Completing online warranty registration will prevent delay in
obtaining warranty coverage. Access the Hatco website at
www.hatcocorp.com, select the Parts & Service pull-down
menu, and click on “Warranty Registration”.
Business 8:00 AM PMto 5:00
Hours: Central Standard Time (C.S.T.)
(Summer Hours: June to September –
8:00 AM PMto 5:00 C.S.T.
Monday through Thursday
8:00 AM PMto 2:30 C.S.T. Friday)
Telephone: (800) 558-0607; (414) 671-6350
E-mail: partsandservice@hatcocorp.com
Fax: (800) 690-2966 (Parts and Service)
(414) 671-3976 (International)
Additional information can be found by visiting our web site at
www.hatcocorp.com.
24 Hour 7 Day Parts and Service
Assistance available in the United States
and Canada by calling (800) 558-0607.
INTRODUCTION
Form No. 3CSFRM-0112
2
CONTENTS
Hatco FR and 3CS heaters are designed to supply temperature-
controlled water to a sink or holding vessel located above the
heater. Water flows by natural convection from the sink or
holding vessel into the heater directly downward into the rear
reservoir. The rear reservoir acts as a soil collection sump.
Debris that could affect the heating element operation settles
out in the sump to be drained away later. The debris free water
flows into the second reservoir in which the heating elements
are mounted. The water is heated and returns upward to the
sink or holding vessel.
All electrical and plumbing connections are factory-assembled
and ready for installation.
Hatco FR and 3CS Water Heaters are products of extensive
research and field testing. The materials used were selected for
maximum durability, attractive appearance and optimum
performance. Every unit is thoroughly inspected and tested prior
to shipment.
This manual provides the installation, safety, and operating
instructions for Hatco Water Heaters. Hatco recommends that
all installation, operating, and safety instructions appearing in
this manual be read prior to installation or operation of a unit.
Safety information that appears in this manual is identified by
the following signal word panels:
WARNING indicates a hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION indicates a hazardous situation which, if not
avoided, could result in minor or moderate injury.
NOTICE is used to address practices not related to
personal injury.
WARNING
CAUTION
NOTICE
IMPORTANT SAFETY INFORMATION
4Form No. 3CSFRM-0112
Units are voltage-specific. Refer to specification label for
electrical requirements before beginning installation.
Connecting unit to incorrect power supply will void product
warranty and may damage unit.
This unit is intended for commercial use only — NOT for
household use.
Do not turn on power to unit until holding vessel has been
filled with water. Dry operation may cause element burnout.
ALWAYS drain holding vessel with power to unit off or
element burnout could occur.
Do not use excessive force when tightening unions or nuts.
Over-tighening and excessive force may cause leaks.
Incoming water in excess of 3 grains of hardness per
gallon (GPG) (0.75 grains of hardness per liter [GPL]) must
be treated and softened before being supplied to water
heater(s). Water containing over 3 GPG (0.75 GPL) will
decrease efficiency, increase energy use, and reduce
operating life of unit through increased lime build-up.
Product failure caused by liming or sediment buildup is
not covered under warranty.
Use only delimers that are non-corrosive to aluminum,
brass, and stainless steel. Damage to unit caused by
corrosive materials is not covered under warranty.
Inspect unit regularly for lime and sediment buildup.
Excessive buildup may affect performance and reduce
operating life of unit.
NSF Criteria
NSF Standard 4 has recently added performance requirements
for food rethermalizing. The requirements mirror the
requirements for food rethermalizing in the FDA Food Code.
The basic requirement is that food reach a temperature of 165°F
(74°C) in a time period of two hours or less.
Appliances that are manufactured for the purpose of
rethermalizing food will need to meet these performance
requirements in order to be listed to NSF Standard 4.
The Hatco FR Series heating unit is specifically made for food
rethermalizing, however, the heating unit is designed to be
incorporated into a hot water bath rethermalizer. Hatco does
not supply the vessel that contains the water, nor the system
which determines how food is placed and held in the vessel.
The Hatco FR unit attaches to the bottom of the vessel and
supplies hot water to the vessel.
Hatco does supply sizing recommendations to enable the
appliance manufacturer to correctly size the FR unit to the
vessel. However, there are variables in the way that the vessel
is manufactured that affect its ability to pass the NSF
performance requirements. The Hatco FR unit is listed with NSF
for construction only. Due to the fact that the FR is only a portion
of a larger system, it is impossible to do performance testing
until the FR unit is incorporated onto the water vessel.
It is the responsibility of the vessel manufacturer to have the
entire rethermalizing appliance tested and listed in accordance
with NSF Standard 4. Simply hanging an NSF listed FR unit on
the appliance does not transfer NSF listing to the entire
appliance.

Product specificaties

Merk: Hatco
Categorie: Heater
Model: FR-9B

Heb je hulp nodig?

Als je hulp nodig hebt met Hatco FR-9B stel dan hieronder een vraag en andere gebruikers zullen je antwoorden


Handleiding Heater Hatco

Hatco

Hatco S-40 Handleiding

9 Juli 2023
Hatco

Hatco 3CS2-3 Handleiding

7 Juli 2023
Hatco

Hatco 3CS-6B Handleiding

5 Juli 2023
Hatco

Hatco FR-9B Handleiding

5 Juli 2023
Hatco

Hatco 3CS-3B Handleiding

5 Juli 2023
Hatco

Hatco 3CS2-4 Handleiding

4 Juli 2023
Hatco

Hatco 3CS2-3B Handleiding

4 Juli 2023
Hatco

Hatco FR2-4B Handleiding

3 Juli 2023
Hatco

Hatco FR2-4 Handleiding

3 Juli 2023
Hatco

Hatco 3CS-4 Handleiding

3 Juli 2023

Handleiding Heater

Nieuwste handleidingen voor Heater

Mestic

Mestic MKK-250 Handleiding

26 April 2024
Mestic

Mestic MKK-400 Handleiding

26 April 2024
Delonghi

Delonghi DCH7093ERBCA Handleiding

25 April 2024
Delonghi

Delonghi MDHS12 Handleiding

25 April 2024
Delonghi

Delonghi HFX30C15.WCA Handleiding

25 April 2024
Delonghi

Delonghi MDHU12 Handleiding

25 April 2024
Delonghi

Delonghi HFX12D03 Handleiding

25 April 2024
Delonghi

Delonghi Dragon 4 TRD40615 Handleiding

25 April 2024
Thermotec

Thermotec AeroFlow Midi 1950w Handleiding

18 April 2024
Everdure

Everdure NPE2400W Handleiding

17 April 2024